Is the fuel tank vent clogged.
Marine fuel tank vent problems.
When you open the vent on an expanded tank fuel vapors will escape.
It was difficult to put gas in the tank.
Taking a look on the outside of the hull and seeing if the vent is even there if it is corroded broken or upside down.
Since we d had more problems as the trip had progressed and thus there was less fuel in the tank we suspected maybe there was a crack in the tank pickup.
Shortly after i had a new fuel tank installed i discovered a problem a boat gas tank vent problem.
To meet the new regulations fuel tanks can no longer be built as an open fuel system.
If the tank is sucked in opening the vent will allow air into the tank to equalize the pressure.
If your boat has diesel engines you ve heard about algae problems with diesel fuel.
The fuel tank vent is located on the outside of the boat normally relatively close to the fill port on the gunwale of the boat.
Then i could fill up just fine.
The fuel had pressurized in the tank in the sun no vent on that tank and when i turned the handle to steer the crack finally opened.
If your boat doesn t have a portable tank but instead an integral tank with a fuel vent that s plumbed to the outside of the boat inspect that vent.
For safety reasons opening the vent should be done off the boat on a level surface with good air circulation in the area and no ignition source present even cell phones.
Actually this algae is sludge a mixture of paraffin and asphalts resulting from the breakdown of the fuel remaining in the tank over a period of time as little as 60 to 90 days where it settles to the bottom of the tank.
Now that portable fuel tanks must be fully sealed gas vapor is unable to vent and has nowhere to escape except to your engine through the fuel line.
Condensation can be another source of water in your tank a situation made worse by ethanol added to marine fuel.
When i was a kid with an a 7 hp sears outboard engine the fuel line once split open on me and sprayed both me and the boat with gas.
A boat fuel tank overflow can be caused by a clog in the vent.
Wasps spiders and other critters are well known for clogging these fittings up and that can significantly affect engine performance.
This builds up pressure within the fuel tank and puts your engine at risk of flooding.
